HOTLINE 0086-29-88606479
  Tel: 86-29-88606479   E-mail: sales@dechuang-auto.com

NEWS

About us

Tips on Model Selection of Radar Liquid Level Meter -Guided wave radar and 26GHz radar

DATE: 2019-11-04
BROWSE TIMES: 19

                                               Tips on Model Selection of Radar Liquid Level Meter  -Guided wave radar  and 26GHz radar level meter


When we select the suitable model of radar level meter, below attentions should be paid on mixing, vacuumizing, power supply and output signal during model selection of radar liquid level meter.

I. Model selection on mixing(stirring)

Guided wave radar can not be used in mixing tank because mixing strength apt to bring rope into propeller or stretch the rod-type guided wave radar, non-contact measurement high frequency or low frequency horn radar is selected.

If the lowest liquid level exceeds the mixing propeller, measurement is not be impacted. If the lowest liquid level is below the the mixing propeller, it should study the fake echo to filter the signal reflected by propeller and ensure measurement not as propeller target.

II. Model selection on vacuum 

Liquid boiling point will be much lower than the standard atmospheric pressure under the condition of vacuum. Liquids from 30℃ to 40℃ start to boil, especially reactor and vaporator. In case of vacuumizing, liquid becomes calm, and vacuumized from 1m to 3m height, with boiled bubble and small water drop. The horn radar is only selected under the condition and made some changes on site.

III. Power supply and input signal

24VDC is used for radar power supply in the market. If users require 220VAC, 220VAC, there are 4-20ma and 485 power input signal. 4-20ma is dominated for wide industrial application.  a few users use 485 for low power consumption occasion on hydrology and water conservancy, torrential flood warning, etc.



Share to
RELATED NEWS / News More
  • Number of clicks: 100
    2020 - 11 - 26
    Instrument Knowledge|Application of radar level transmitter in natural gas chemical industry chainNatural gas chemical industry is one of the branches of the chemical industry. It is an industry that uses natural gas as a raw material to produce chemical products. Natural gas chemical industry can also be attributed to petrochemical industry. Generally include the purification and separation of natural gas and chemical processing. Through purification, separation and cracking, steam reforming, oxidation, chlorination, sulfurization, nitration, dehydrogenation and other reactions, it can be made into synthetic ammonia, methanol and its processed products (formaldehyde, dimethyl ether, acetic acid, olefin, etc.), acetylene and its deep processing Products, etc. Purification and separati...
  • Number of clicks: 291
    2020 - 11 - 24
    There are many corrosive liquid used in various chemical industries, then the corrosive liquid level measuring instrument are required commonly, For radar type level sensor, we have below 3 types of anti-corrosion:1. DCRD1000A1, PTFE corrosive proof radar level sensor2. DCRD1000A2, PFA corrosive proof radar level sensor3. DCRD1000C5, FEP corrosive proof radar level sensorXi’an Dechuang Electrical Technology Co., Ltd
  • Number of clicks: 1001
    2020 - 11 - 19
    120G frequency modulated continuous level measurements radar level meter was successfully applied to the level measurement of aluminum foil waste in high temperature kilns The measuring medium is various aluminum blocks, aluminum foil scraps, etc.The aluminum foil is very light during the feeding process, and there are many flying materials and suspended aluminum foils, and the temperature in the furnace is as high as 700-800 degrees. This environment also has a great impact on the installation of the continuous radar level meter. After technical discussions with us, the customer finally chose our DCRD1000B3 120Ghz radar level meter high temperature type, combined with specific site conditions, added a section of extension pipe and quartz glass for heat insulation, the technical ...
  • Number of clicks: 352
    2020 - 11 - 17
    Air purge+Nuzzle ,  Universal joint:The necessary adjunct when measuring the level of bulk solid in silos bins and tanksWhen radar level transmitter measure the level of solid medium, such as grains, cement powders, solid particles,  the solid material  will form a stockpile or hopper in the silo when feeding  or undloading. Then the antenna of the radar level transmitter need to perpendicularly alignment to the medium surface,  if the material is uneven,  and the heap angle is large then the universal joint flange is needed to adjust the horn angle to aim the charge level.(Due to the inclination of the solid surface it will cause the problem of  echo decay or even the signal loss.)When measuring the bulk solids, there will bring very heavy dust.  we...
  • Number of clicks: 201
    2020 - 11 - 13
    Application case | 120G frequency modulated radar level gauge DCRD1000B successfully applied to the measurement of liquid level in the pharmaceutical and chemical reactor The chemical and pharmaceutical industry has the characteristics of complex production technology, many varieties, long process flow, many types of equipment required, many raw and auxiliary materials, and most of them are flammable, explosive and toxic, and have the characteristics of stimulating corrosion. As a liquid level measuring instrument installed on a storage tank or reactor, the liquid level gauge is also faced with technical performance challenges in the face of the complex structure and harsh working conditions of the equipment in the pharmaceutical and chemical industry. DCRD1000B series, 120GHz fr...
Email:sales@dechuang-auto.com
Adress:
Tel:86-29 88606479
Fax: 86-29 88385903
B203, Gazelle Valley, No.69 Jinye Rd, Hi-tech zone, Xi'an, Shaanxi Province, P.R.China. 710077
Copyright ©2018 - 2019 Dechuang Electrical Technology Co., Ltd SITEMAP
Rhino Cloud Provides Enterprise Cloud Services
犀牛云提供云计算服务